01 of 08
What You Need
Rotisserie turkey is the perfect way to cook that holiday meal. Self-basted, moist, and tender, this is one of the best ways to cook a turkey, but before starting you have to determine whether the rotisserie kit for the grill can hold the turkey. Most rotisserie kits are designed to hold up to 15 pounds so a larger turkey will bend the rod and it won't turn properly. Check with the grill's manufacturer before considering this method.
The next step is to calculate the cooking time. The... target temperature for the grill is between 325 to 350 degrees F/160 to 175 degrees C so the cooking time is 15 to 20 minutes per pound (500g), so do the math first. This will determine the amount of fuel needed and for how long the grill will need to burn. Just as a general guideline and calculated on the safe side, a 12-pound (5.5 kg) turkey will take 4 hours and a 15-pound (7 kg) turkey will take 5 hours. It's not recommended to cook a turkey larger than 18 pounds (8 kg) on a rotisserie. The weight and size become prohibitive as the turkey gets larger. Also, most gas grills cannot accommodate too large of a bird.
You will need:Continue to 2 of 8 below.
02 of 08
To begin, set up the rotisserie kit on the grill. This is typically an easy operation that requires 10 minutes and a screwdriver. Of course, different grills and rotisserie kits have different arrangements, so read the instructions.
Depending on the layout of your grill either remove the center cooking grate (you can remove them all) and place an aluminum pan directly under where the turkey will be. This might be a challenge depending on the design of the burners but you don't need a large... pan. Most all of the drippings from the turkey will fall from the widest point of the bird so the pan only needs to be 5 to 6 inches wide. If you can secure a drip pan under the bird you can catch the drippings for gravy. Remember to fill the pan half full of water to prevent the drippings from burning.
Next, comes the preparation of the turkey. Remove the contents from the inside and cut off any loose skin. To increase tenderness and moisture, brine the turkey but this step isn't mandatory. You can also use a turkey marinade. It is also helpful to truss the turkey like you would a chicken to hold it together better on the rotisserie.Continue to 3 of 8 below.
03 of 08
Preparing the Rotisserie Rod
The first problem of putting something large like a turkey on a rotisserie rod is getting the placement right. This process is very difficult hovering over the grill, so it helps to mark the center of the rod over the grill before putting the bird in place. To mark this place, you can use a lemon, an apple or an onion or pretty much anything that can be threaded on the rod. Lemon adds a nice flavor -- as the rod heats, the lemon cooks, and releases flavor and moisture into the middle of the... turkey.
As you can see from the picture, the lemon is centered in the grill, just above the aluminum drip pan which is where the widest part of the turkey should be.Continue to 4 of 8 below.
04 of 08
Securing the Turkey
It is important that you get the turkey secured to the rotisserie rod. This is the most challenging step in the process, but if you do it right you won't have any more trouble with it. Since a turkey has many parts that are loose, you need to secure not just the bird, but the legs and the wings. For this reason, you might want to truss the turkey as you would a chicken, but you might not need to if you can get everything loaded in the right place.
It is easier to place the turkey on a platter... or cutting board then run the rod (not moving the lemon) through the bottom of the turkey and out through the neck. This puts the lemon safely inside. Put the second fork on the rod, pointing towards the turkey and bring it through. It might seem like you don't have enough hands for this operation but be patient. You need to make sure that the whole turkey is tight in the forks before proceeding. Press the forks together, gathering up the legs and wings in the forks so that they are held in place. If you have a dangling wing it will flop around and likely burn.
Once you have the bird secured, tighten the screws on the fork. Make sure they are very tight. Roll it around a little to make sure that the legs and wings hold. Don't worry about the balance, we'll get to that in a minute.
If you look at the picture above you will see the wings tied together to prevent from flopping around.Continue to 5 of 8 below.
05 of 08
Setting the Counterbalance
Some rotisserie kits do not have or need counterbalances. If yours does, make sure you follow the next two paragraphs.
Balancing the turkey on the rotisserie makes sure it cooks evenly and doesn't burn out the rotisserie motor. If the rotisserie kit has a counterbalance, then there should be no trouble getting it balanced. If not, there isn't too much you can do about it. Turkeys are heavier on the back than on the breast side.
To balance the turkey remove the motor from the bracket and... place the rotisserie rod with the turkey on the grill so that it moves freely. The heavy side will drop towards the bottom. Pull the counterbalance straight up and tighten. It won't balance perfectly, but you will offset the weight enough to allow the motor to handle the load easily.
Now attach the motor and turn it on. Make sure that the turkey doesn't move on the rod and that it turns easily. Once you have determined that it will stay put, you can start the grill.
Rotisserie turkey is grilled indirectly. This means that the burners directly underneath the turkey are off and that all the heat is being provided by the other burners. If the burners under the turkey are on, you will get flare-ups, plus this is where the drip pan should be placed to catch the drippings. Make sure to half fill the drip pan with water to prevent the drippings from burning. The drippings will cook so watch to make sure the pan doesn't dry out.
Adjust the heat on the grill until the temperature reaches around 350 degrees F. It is not a good idea to wander away too long. It is best to keep an eye on the turkey for the first few minutes to make sure that everything is going right.Continue to 6 of 8 below.
06 of 08
Basting the Turkey
You have probably noticed that we haven't done much to flavor the turkey. Now is the time to start adding flavor and we will do this by basting the outside of the bird. You can add whatever you like, but it can be as simple as lemon, rosemary and sage.
A good baste needs to have flavor and oil. The oil (which can be any fat like butter or olive oil) helps hold in the moisture and browns the surface of the turkey. Try:
- 1 cup olive oil
- 1 cup lemon juice
- 2 tablespoons fresh rosemary leaves
- 2... tablespoons fresh sage, chopped
Break up the rosemary leaves a little with a rolling pin to get the oils out. Add them to the olive oil and lemon juice. The acid in the lemon juice is going to bring out the rosemary flavor and blend it with the olive oil.
Start basting the turkey after about an hour on the rotisserie. Continue basting every 30 minutes until the turkey is nearly done.Continue to 7 of 8 below.
07 of 08
Checking the Temperature
At a cooking temperature between 300 and 350 degrees F, it takes a turkey around 20 minutes per pound to cook. A 15-pound turkey should take around 5 hours to cook. When the internal temperature of the turkey reaches 160 to 165 degree F it is time to get it off the heat.
As the turkey cooks, you may notice that it tends to plump up. As the turkey gets close to being done this plumping goes away and the turkey shrinks. Also, the skin of the turkey will be a dark, golden brown. These are clues that... it is nearly done and time to start checking the temperature.
To test the internal temperature, use a meat thermometer and take a reading in at least two different places. Test the center of the turkey breast and in the thigh right above the drumstick. These are the densest parts of the turkey and the slowest to cook. When both of these places read above 165 degrees F, it is time to take the turkey off the grill.
Have a hot pad or fireproof glove and a platter or cutting board ready beside the grill. Remember that the metal rod of the rotisserie is going to be about 300 degrees F when you grab it. It is easy to burn yourself so be careful.
When taking the rotisserie rod and turkey off the grill start by turning off the burners and rotisserie motor. It is usually easier to lift up and pull off the motor first to get it out of the way. Get a good hold of the rod on both ends and place the turkey on your platter and cutting board.
Removing the drippings pan can be difficult. Use a turkey baster to siphon off most of the liquid to transfer inside to make gravy.Continue to 8 of 8 below.
08 of 08
Removing the Turkey
Using your hot pad or glove, loosen the screw on the fork opposite from the handle and slide it off. Now the turkey is free to move. Holding the turkey on the platter or cutting board, slowly pull the rod from the turkey. The lemon we put inside will stay with the turkey and you can remove it before carving. Cover the turkey with aluminum foil and a kitchen towel and let the turkey rest for 20 to 30 minutes allowing the juices flow back into the meat. Once this time is up, carve the turkey as... normal.
One last piece of advice: You have been cooking a whole turkey indirectly on your grill. If there was no drip pan the drippings from the turkey will have fallen into your grill without burning off. It is a good idea to light up the middle burner and get it burned off or next time you use your grill, this might cause a pretty big flare-up.